|
|
||||||||
a Dep. of Soil and Crop Sci., Colorado State Univ., Fort Collins, CO 80523
b Dep. of Agric. and Resour. Econ., Colorado State Univ., Fort Collins, CO 80523
* Corresponding author (rkhosla{at}colostate.edu)
Received for publication August 25, 2003.
| ABSTRACT |
|---|
|
|
|---|
Abbreviations: GIS, geographic information systems OM, organic matter SSMZ, site-specific management zone SSMZ-CYG, site-specific management zoneconstant yield goal SSMZ-VYG, site-specific management zonevariable yield goal VRT, variable-rate technology
| INTRODUCTION |
|---|
|
|
|---|
The potential for improved profitability due to variable-rate N application depends on identifying areas in the field where additional N inputs will increase revenue on a scale that is greater than the added costs and/or identifying areas where reducing N inputs will decrease costs on a scale that is greater than potential revenue reduction correlated with lower grain yield (Snyder et al., 1999). Therefore, the economic feasibility of variable-rate N application is focused on whether increases in gross revenue or decreases in N input costs outweigh the added cost of technologies or services needed for variable-rate N application (Ferguson et al., 1999; Thrikawala et al., 1999).
Thrikawala et al. (1999) reported that the profitability of variable-rate N application increased above that of uniform N application as area and in-field soil variability increased. However, additional information and application expenses are involved when managing spatial variability occurring throughout a field. Review of literature suggested that most studies incorporated the information costs (i.e., soil sampling, developing variable-rate application maps) but ignored the additional application and equipment costs needed for variable-rate N application (Swinton and Lowenberg-DeBoer, 1998; Thrikawala et al., 1999).
There are few analyses of revenues, costs, and returns associated with variable-rate applications, and the results of the few existing analyses have not been communicated well to growers interested in practicing variable-rate application of N fertilizer. One approach has been an economic study of returns based on variation in grain yield and N rates using partial budgets (Swinton and Lowenberg-DeBoer, 1998). Other studies have used quadratic functions to quantify corn yield response (Snyder et al., 1997, 1999). Similarly, some studies have used simulation models to calculate grain yields, optimal N rates, revenue gains, costs, and net returns (Fraisse et al., 1999; Paz et al., 1999; Thrikawala et al., 1999).
A common factor in the majority of these above studies is that they use grid soil sampling as the primary strategy on which to base a variable-rate N application. In principle, grid-samplingbased N application seems logical, but economically there are limitations. Grid sampling is labor intensive, time consuming, and must be performed every growing season for N levels in fields subject to variable-rate N fertilization (Gotway et al., 1996; Khosla et al., 1999; Fleming et al., 2001; Nolan et al., 2001; Khosla et al., 2002; Koch and Khosla, 2003). Watkins et al. (1999) reported a $43 ha1 lower return in potato (Solanum tuberosum L.) production under variable-rate N application compared with uniform application. In their study, the cost of grid soil sampling outweighed any benefits realized by variable-rate N application. Other studies have likewise shown that the cost of grid soil sampling is significantly higher than conventional composite sampling (Khosla et al., 1999; Thrikawala et al., 1999; Yang et al., 1999; Batte, 2000; Fleming et al., 2001; Khosla et al., 2002).
The profitability potential of variable-rate N management is significantly enhanced if the initial means of preparing prescription application maps are less expensive (Peterson and Wollenhaupt, 1996; Koch and Khosla, 2003). Minimal-cost, yet effective approaches for managing spatial variability are needed. Recent research in precision farming has focused on site-specific management zones (SSMZ) as a means to generate nutrient application maps and improve N management in cropping systems (Fleming et al., 2000, 2001; Luchiari et al., 2001; Khosla et al., 2002). Generally, these studies indicate that SSMZ has the potential to be an effective alternative to grid soil sampling for quantifying and managing spatial variability. However, lacking is an economic analyses of SSMZ compared with traditional uniform N management.
No studies have been reported in the western Great Plains region demonstrating the economic feasibility of variable-rate N application utilizing SSMZ. An on-farm, enterprise-based field study was conducted in Colorado to assess the economic feasibility of variable-rate N application utilizing SSMZ. Specific objectives were to: (i) evaluate the economics of four N management strategies, (ii) assess net-return sensitivity of each N management strategy as influenced by changes in grain yield and commodity prices, and (iii) analyze the N management strategies under farmer vs. custom-applied scenarios.
| MATERIALS AND METHODS |
|---|
|
|
|---|
|
Nitrogen application rates for each N management strategy were calculated using an N recommendation algorithm for irrigated corn (Mortvedt et al., 1996)
![]() | [1] |
A constant yield goal of 12.54 Mg ha1 was the expected yield (EY in Eq. [1]) for the uniform, grid-based, and SSMZ-CYG N management strategies and was determined based on farmer's knowledge of the field.
Variable yield goals were subjectively determined by consultation with the cooperating farmers based on their experience and previous years of yield maps. For the SSMZ-VYG N management strategy, expected yields were 13.80, 11.91, and 10.03 Mg ha1 in the high, medium, and low productivity zones, respectively, over all three site-years.
Four experimental strips spanning the length of the field represented the N management strategies and were laid out so they traversed all three management zones (high, medium, and low productivity) at least once. Each N management strategy was replicated four times, using a completely randomized design at the furrow-irrigated study site (Site-Years I and II). The center-pivotirrigated study site, Site-Year III, had only one experimental strip for each N management strategy. The N fertilizer, urea ammonium nitrate (UAN 3200), was sidedressed 30 to 35 d after emergence between corn vegetative growth stages V6 and V8 (Ritchie et al., 1997). Grain yields were recorded using a Green Star (Deere and Co., Moline, IL) instantaneous yield-monitoring systems. Grain yield data were cleaned using a comprehensive multistep process (Hornung, 2004). Yield maps were created, and grain yields for individual treatment strips and zones were extracted using MapInfo (MapInfo Inc., Troy, NY) GIS software. Mean grain yields in each zone for the various N management strategies were used for economic analysis.
Being a field-scale study, the proportions of management zones (high, medium, and low) in each experimental strip were different. To compare the profitability of each N management strategy, the proportions of management zones were standardized to the proportion of management zones across the entire field. For the furrow-irrigated site (Site-Years I and II), the proportions of high, medium, and low management zones were 0.305, 0.345, and 0.350, respectively, and 0.337, 0.419, and 0.244, respectively, for the center-pivotirrigated site (Site-Year III) (Fig. 1). For grid-samplingbased N management strategy, it was assumed that the variability in soil and crop properties observed in the experimental strip was representative of the entire field. The mean N rate, grain yields, and net returns for the grid-based N management strategy were the weighted mean of the N rates, grain yield, and net returns, respectively, for the entire experimental strip.
For Site-Year I and II, analysis of variance (ANOVA) was performed on weighted grain yields observed for the four N management strategies to test for significance difference (P < 0.05). When ANOVA results indicated significant treatment effect, mean separation was performed using LSD (SAS Inst., 2001). For Site-Year III, with no replication, geostatistics was performed on grain yield data to test for spatial dependency using Moran's I. In the absence of spatial dependency, the grain yield data were subsampled using a sample size of n = 40 within each management zone (Hornung et al., 2003) and analyzed as for Site-Year I and II.
Economic Analysis
For this study, each N management strategy was treated as a separate enterprise. The estimated net returns to the land and management were compared to establish the most profitable N management strategy. Crop enterprise budgets were constructed to assess the economics of uniform vs. variable-rate N fertilizer applications over the three site-years. The primary purpose of an enterprise budget is to estimate revenue, costs, and net return for a common base unit (i.e., per hectare), allowing easy comparisons across different enterprises (Kay and Edwards, 1999). Partial budget analysis compares only costs that change from one system to another. We used enterprise budget analysis, which shows all the variable costs associated with a system. Fixed costs were ignored, as they would be with partial budget analysis. However, variable costs that do not change were included to add context to the study.
The first step in economic analysis was to obtain production summaries from the farm cooperators managing each study site. Production summaries included actual management practices, operation schedules, and equipment specifications specific to each study site. Management practices and operation schedules included type and number of tillage operations, type and amount of fertilizer and pesticide applications, seeding rates, irrigation practices, and harvest operations. Equipment specifications included purchase price, salvage value, useful life, annual use, expected life, repairs, implement width, speed of operation, operating efficiency, and coverage per hour of use. Likewise, actual farm-wide use for each piece of equipment was collected from each cooperator to determine equipment's annual use. Fertilizer, pesticide, seed, and variable-rate N application costs were collected from cooperating farmers and three fertilizer retail dealers in eastern Colorado to obtain average crop input costs. Costs associated with variable-rate N application included grid soil sampling, management zone delineation, custom application, and variable-rate control system cost. Table 1 presents cost of materials and services used in all three site-years.
|
|
When considering the variable-rate N management strategies, the costs associated with variable-rate N management were both fixed and variable (Batte, 2000). Fixed costs accounted for the interest on investment, depreciation, etc., of the GPS receiver, on-board computer, software, data storage card, variable-rate control system, and variable-rate applicator (tractor and cultivators). These were fixed costs amortized over a useful life of 10 yr and spread over 486 and 850 ha of corn grown on the furrow-irrigated (Site-Years I and II) and center-pivotirrigated (Site-Year III) farms, respectively. There was also a cost associated with speed reduction to variably apply N fertilizer resulting in less coverage per hour. Speed reduction is required to minimize lag time associated with frequent changes in variable N application rates. These are fixed costs that farmers would incur practicing variable-rate N application (farmer-applied scenario). However, farmers may choose to custom-hire the variable-rate N application instead of owning the variable-rate equipment (custom-applied scenario). For this scenario, the cost associated with the VRT equipment is recovered by the custom service as a higher application charge per hectare to the farmer. The custom application cost was variable and appeared in the material costs.
Grid soil sampling was also a variable cost that included labor, sample analysis, and generation of a digital application map. Conversely, management zone delineation was a fixed cost that included the cost of aerial imagery, farmer and agronomist consultation of topography and past management experiences, and generation of a digital application map. Management zone delineation was considered a durable investment, and the cost was amortized over a useful life of 5 yr (Batte, 2000; Fleming et al., 2000, 2001; Heermann et al., 2002; Khosla et al., 2002; B. Gibson, personal communication, 2002; D. Slinger, personal communication, 2002). Composite soil sampling for each zone was a separate charge and considered to be a variable cost. The cost of a yield-monitoring system was assumed to be a fixed cost as yield monitors are now coming as standard equipment for most brand names. For all N management strategies, yield monitor was added to the combine purchase price whether or not the farmer practiced variable-rate N application.
Net returns for each management zone (high, medium, and low) within each N management strategy were computed by subtracting total operating costs and total ownership costs from gross revenue. Weighted mean net returns were a function of management zone proportion across the entire field and should be interpreted as returns to land and management. Weighted mean net returns were used to compare economic differences for N management strategies, observe trends (i.e., in net returns) between each site-year, and establish the most profitable N management strategy. Additional returns due to variable-rate N management were calculated as the difference between variable and uniform N management. A sensitivity analysis of net returns was performed for a broad range of grain yield and commodity price scenarios (Janosky et al., 2002). Simulated grain yields fluctuated incrementally from 9.4 to 13.8 Mg ha1 while corn price fluctuated incrementally from $68.95 to $118.20 Mg1.
| RESULTS AND DISCUSSION |
|---|
|
|
|---|
|
Total Costs
Overall, the lowest total cost of production was $788.37 ha1 for the custom-applied SSMZ-VYG N management strategy (low zone) while the highest total cost was $907.52 ha1 for the farmer-applied grid-based N management strategy. Several key findings were observed when comparing total cost of production between N management strategies. The low productivity zone in the SSMZ-VYG N management strategy had the lowest expense ($788.37 to $865.15 ha1) compared with that of other management zones and was consistent among site-years. This can be attributed to the optimum N rate application (significantly less than the other N management strategies) on low productivity zones for the SSMZ-VYG N management strategy. The grid-based N management strategy was found to be the most expensive form of variable-rate N management attributed to relatively higher N rates (two out of three site-years) and grid soil-sampling costs associated with the strategy ($24.70 ha1) (Table 3).
Comparing the two N application scenarios (i.e., farmer-applied and custom-applied), farmer-applied variable-rate N application was found to be less profitable due to costs associated with the farmer owning and operating the variable-rate applicator (i.e., DGPS receiver, variable-rate controller, tractor, cultivator, etc.). This finding contradicts the general perception that farmer-owned operations are either equal or less expensive than custom services (Gutierrez and Dalsted, 1992; R. Johnson, farmer, personal communication, 2002). However, there was a $5.56 ha1 cost increase for a custom service to variably apply N vs. uniformly applying N (Table 1). Interestingly, there was only a $2.92 to $4.80 ha1 increase for the farmer to invest in the VRT equipment (i.e., variable-rate control system and software) needed to variably apply N. This study revealed that total costs associated with the variable-rate fertilizer applicator (i.e., tractor depreciation, interest, coverage reduction, fuel, etc.), not the VRT equipment, resulted in higher cost for farmer-applied variable-rate N application. More specifically, purchase prices for the tractors used in this study ($113000 and $85000) were the main influence for high ownership (fixed) costs associated with the variable-rate N fertilizer applicator. High total costs associated with the farm equipment used in this study will influence net returns for the farmer-applied scenario.
The size of the farm was also found to be an important factor governing costs associated with VRT equipment. In this study, total farm sizes were 486 ha for Site-Years I and II and 850 ha for Site-Year III. Larger farm size (850 ha) allowed fixed costs associated with VRT equipment to be spread over a larger area, thereby decreasing the fixed expense of VRT equipment from $4.28 to $2.44 ha1 for the farmer-applied scenario. This decline in cost as farm size increased is known as economics of scale (Batte, 2000). Such economics may justify ownership of durable capital investments (i.e.,VRT equipment) and allow adoption of this technology on larger farms. Similar results regarding the relationship between farm size and fixed costs have been reported (Thrikawala et al., 1999; Batte, 2000).
Mean Net Returns
Weighted mean net returns based on the farmer's actual corn price across all N management strategies and site-years ranged from $38.45 to $396.07 ha1 (Table 3). Comparing variable and uniform N management strategies at the farmer's corn price, the SSMZ-VYG N management strategy produced the highest net return per hectare under both farmer-applied and custom-applied scenarios in Site-Years I and II. Additional returns due to variable N management using the SSMZ-VYG N management strategy over uniform N application ranged from $25.60 to $38.35 ha1 in Site-Years I and II. These results support the findings of Prato and Kang (1998) that variable-rate N management is more profitable than uniform N management under continuous corn cropping systems. Factors that contributed toward additional returns for this strategy were grain yield, N fertilizer savings, and recovery of variable-rate application expenses (Tables 1 and 3).
For Site-Year III, the SSMZ-CYG and SSMZ-VYG N management strategies showed no difference (P < 0.05) with respect to grain yield. However, the SSMZ-CYG strategy produced the highest net return per hectare under both N application scenarios (i.e., farmer-applied and custom-applied) (Table 3). Additional returns due to variable N management using the SSMZ-CYG N management strategy over uniform application were $32.89 and $33.43 ha1 for the farmer- and custom-applied scenarios, respectively (Table 3). The SSMZ-VYG N management strategy resulted in additional returns to variable N management over uniform N application of $27.48 and $27.98 ha1 for the farmer- and custom-applied scenarios, respectively. The profitability of the SSMZ-CYG and SSMZ-VYG N management strategies is attributed to significant N fertilizer savings (3746%) and recovery of variable-rate N application expenses (Tables 1 and 3). Increased N fertilizer application (30%), grid-sampling costs ($24.71 ha1), and additional variable-rate N application costs for the grid-based N management strategy resulted in the lowest net return among all N management strategies. This corresponds to previous economic feasibility studies reported by Thrikawala et al. (1999) and Watkins et al. (1999).
Sensitivity Analysis
Market prices and grain yields fluctuate extensively over time, and negative net returns are not uncommon in grain production when government payments, commodity premiums, and price hedging are excluded from economic analysis (Janosky et al., 2002). For example, market prices obtained by the cooperating farmers ranged from $84.65 to $111.04 Mg1 while the 5-yr average price was $83.48 Mg1. Likewise, irrigated corn yields in this region vary from year to year. To illustrate the effect of various corn price and grain yield combinations on net return, a sensitivity analysis was performed to show net-return sensitivity for the four N management strategies in Site-Year I (Table 4). Results for the SSMZ-VYG N management strategy, the most profitable strategy in Site-Year I, are discussed to illustrate the effects of various price and yield combinations.
|
Farmer- and Custom-Applied Scenarios
A few key points should be discussed for farmer-applied vs. custom-applied variable-rate N applications. In this study, net returns were slightly lower ($4.94 to $6.83 ha1) for the farmer-applied scenario (Table 3). However, variable-rate application of N fertilizer is not necessarily a separate farm operation in irrigated cropping systems as we considered it. It is usually coupled with an existing cultivation operation ($15.94 to $16.60 ha1) where N fertilizer can be sidedressed (L. Baucke, personal communication, 2002; R. Johnson, personal communication, 2002). In this case, the only additional cost to farmer-applied variable-rate N application would be associated with the VRT equipment ($2.92 to $4.80 ha1) and any efficiency reductions related to variable-rate N application ($2.84 to $3.28 ha1). If a decision was made to variably apply N using a custom service, there would be a custom charge (approx. $15.44 ha1) plus the fixed and variable costs (i.e., depreciation, interest, fuel, etc.) on the cultivation operation ($15.94 to $16.60 ha1). Therefore, combining VRT equipment with an existing cultivation or uniform N fertilizer application ($22.80 to $23.58 ha1) would be more profitable than hiring a custom service to variably apply N fertilizer ($31.38 to $32.04 ha1). Moreover, economics of scale may justify ownership of VRT equipment and allow adoption of this advanced technology (Thrikawala et al., 1999; Batte, 2000). Timeliness and quality of application may also deter hiring a custom service (Dalsted and Gutierrez, 1992). However, there is a fixed cost associated with management of VRT. Further, there is typically is a considerable learning process necessary for efficient and successful use of VRT. Development of such knowledge could be substantial, and some farmers may find it more feasible to hire a custom service to manage the advanced technology needed for variable-rate N application. Similar studies have recognized this cost associated with management of VRT (Snyder et al., 1999; Batte, 2000).
| CONCLUSIONS |
|---|
|
|
|---|
Although this study measured the economic benefits related to alternative N management strategies, associated studies are revealing the environmental advantages of utilizing SSMZ and VRT (Batte, 2000; Khosla et al., 2002; Stafford and Werner, 2003). These studies have suggested that decreasing N fertilizer using VRT may reduce environmental pollution resulting from agriculture. Adopting SSMZ and VRT has the potential to create a more environmentally friendly, profitable, and sustainable agriculture.
| ACKNOWLEDGMENTS |
|---|
| NOTES |
|---|
|
|
|---|
| REFERENCES |
|---|
|
|
|---|
This article has been cited by other articles:
![]() |
M. Bridges, W. B. Henry, D. L. Shaner, R. Khosla, P. Westra, and R. Reich Spatial Variability of Atrazine and Metolachlor Dissipation on Dryland No-tillage Crop Fields in Colorado J. Environ. Qual., October 23, 2008; 37(6): 2212 - 2220. [Abstract] [Full Text] [PDF] |
||||
![]() |
J. L. Ping, R. B. Ferguson, and A. Dobermann Site-Specific Nitrogen and Plant Density Management in Irrigated Maize Agron. J., June 23, 2008; 100(4): 1193 - 1204. [Abstract] [Full Text] [PDF] |
||||
![]() |
K.-I. Kim, D. E. Clay, C. G. Carlson, S. A. Clay, and T. Trooien Do Synergistic Relationships between Nitrogen and Water Influence the Ability of Corn to Use Nitrogen Derived from Fertilizer and Soil? Agron. J., May 7, 2008; 100(3): 551 - 556. [Abstract] [Full Text] [PDF] |
||||
![]() |
J. A. Taylor, A. B. McBratney, and B. M. Whelan Establishing Management Classes for Broadacre Agricultural Production Agron. J., September 11, 2007; 99(5): 1366 - 1376. [Abstract] [Full Text] [PDF] |
||||
![]() |
E. L. Nail, D. L. Young, and W. F. Schillinger Government Subsidies and Crop Insurance Effects on the Economics of Conservation Cropping Systems in Eastern Washington Agron. J., April 4, 2007; 99(3): 614 - 620. [Abstract] [Full Text] [PDF] |
||||
![]() |
Y. Miao, D. J. Mulla, W. D. Batchelor, J. O. Paz, P. C. Robert, and M. Wiebers Evaluating Management Zone Optimal Nitrogen Rates with a Crop Growth Model Agron. J., April 11, 2006; 98(3): 545 - 553. [Abstract] [Full Text] [PDF] |
||||
![]() |
A. Hornung, R. Khosla, R. Reich, D. Inman, and D. G. Westfall Comparison of Site-Specific Management Zones: Soil-Color-Based and Yield-Based Agron. J., March 2, 2006; 98(2): 407 - 415. [Abstract] [Full Text] [PDF] |
||||
![]() |
M. Mzuku, R. Khosla, R. Reich, D. Inman, F. Smith, and L. MacDonald Spatial Variability of Measured Soil Properties across Site-Specific Management Zones Soil Sci. Soc. Am. J., August 25, 2005; 69(5): 1572 - 1579. [Abstract] [Full Text] [PDF] |
||||
![]() |
D. Inman, R. Khosla, D. G. Westfall, and R. Reich Nitrogen Uptake across Site Specific Management Zones in Irrigated Corn Production Systems Agron. J., January 1, 2005; 97(1): 169 - 176. [Abstract] [Full Text] [PDF] |
||||
| ||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||||
| HOME | HELP | FEEDBACK | SUBSCRIPTIONS | ARCHIVE | SEARCH | TABLE OF CONTENTS |
| The SCI Journals | Crop Science | Vadose Zone Journal | |||
| Journal of Natural Resources and Life Sciences Education |
Soil Science Society of America Journal | ||||
| Journal of Plant Registrations | Journal of Environmental Quality |
The Plant Genome | |||